Inferior spikes do this
Release time:
2020-08-14
Suppression of Inferior Spikes Do This
In the east corner of the production area of Spike Health Technology Company, there is a very inconspicuous building. From below, only a few pipes with uneven thickness can be seen on the top and the slogan "Emphasize Environmental Protection and Promote Sustainable Development" with red letters on the yellow bottom on the stainless steel guardrail. Walking up, you can only see a few closed pools and a small room, on the table in the small room are stacks of documents and testing tools such as test tubes and glass bottles. This is the peak and healthy sewage treatment station. The production sewage of the whole factory area is concentrated here. After adjustment (PH adjustment), pre-acidification, anaerobic, anoxic, aerobic (aeration), precipitation and other links, it is discharged into the pipe network after reaching the special discharge standard. Yin Zhiwu, executive deputy general manager of
Peak Health, said that since the sewage treatment station in Wucheng District has not been built, Peak Health cannot realize the discharge of pipes. However, relevant national laws have strict requirements on the discharge of water pollutants from the extracted pharmaceutical industry, and the discharge of sewage must reach the special discharge limit, the chemical oxygen demand (COD ) must be below 50 mg / L.
Equal emphasis on enterprise development and environmental protection has been the philosophy of Peak Health since its establishment. On the basis of the original environmental protection facilities, Jianfeng Health carried out technical renovation of waste gas collection and treatment facilities on the basis of the original environmental protection facilities. At the same time, a sealing cover was added to the sewage treatment station to realize the closed collection of waste gas. Since the trial operation of this facility 5 in mid-February, the overall effect has been obvious. The original treatment tank would emit an unpleasant smell during work, but now the smell has obviously decreased.
At the beginning of 2016 , according to the arrangement of the pharmaceutical company, the product development department moved to Qiubin factory, where the small and pilot tests of product research and development were carried out. For this reason, Qiubin Factory has carried out renovation and upgrading of sewage treatment facilities. The high-concentration waste liquid collected in the experiment is regularly sent to companies with relevant qualifications for treatment. The waste water generated by washing bottles and tanks at ordinary times enters the regulating tank for treatment through pipelines. The toxic and harmful gases produced during the experiment are also treated by the new waste gas treatment tower and discharged after meeting the atmospheric emission standards. According to the requirements of the environmental protection department, the sewage pipes of the whole plant have also been changed into open channels. "In the event of a leak in an underground pipe, it often takes a lot of time and effort to investigate, which is not conducive to regulation and will also extend the pollution control time. After the change to an open channel, all the pipes are clear at a glance, which can detect problems in a timely manner and also facilitate the supervision of environmental protection departments." Sheng Junyong, an environmental member of the production department of Qiubin Factory, explained the reason for the establishment of the open channel.
2015 , has inherent advantages in environmental protection. Each workshop is equipped with a pretreatment tank. The high-concentration sewage is discharged into the collection tank after pretreatment. After a series of treatment processes, it is discharged after reaching the third-level discharge standard and is included in the municipal sewage pipe network. There is also an emergency pool in the sewage treatment station. If the treated sewage does not meet the discharge standard or there is an emergency, the treated sewage will be discharged into the emergency pool first, and then returned to the collection pool for treatment before discharge.
PAC , PAM , ferrous sulfate and other chemicals to adjust the PH value of sewage, and the other part is the environmental protection bureau's pollution source online monitoring system. Zhang Baoping, deputy director of
700 tons. In terms of tail gas and solid waste treatment, Jinxi Pharmaceutical Factory has a tail gas incinerator and collection device, a special solid waste storage facility, and entrusts a unit with relevant qualifications to carry out regular treatment to avoid pollution to water and soil.
PH value detection on the outlet every day, and COD and other content detection - 2 times a week, ensure that sewage is discharged up to the standard; set up special personnel to be responsible for the investigation and supervision of environmental safety hazards, treatment and operation management of pollution treatment facilities, and conduct environmental protection assessment; organize relevant personnel to learn environmental protection related laws and regulations from time to time, so as to consciously abide by them in production and operation; sign safety and environmental protection responsibility letter every year, decompose and implement it to each team and individual, and clarify their respective responsibilities; implement clean production technology to reduce pollutant discharge, production arrangements to increase production volume, improve product yield, energy saving and consumption reduction.
, the Jinxi Pharmaceutical Factory project passed the environmental protection acceptance, and the two pharmaceutical factories of Qiubin and Jinxi passed the cleaner production review and environmental system certification, and the environmental protection facilities were operating normally. Every year, Jianfeng Pharmaceutical invests a lot of money in the renovation of environmental protection facilities and regular maintenance. The environmental behavior level of the enterprise has been rated as green (excellent environmental behavior) for several consecutive years. Jianfeng Health is also actively doing a good job in environmental protection acceptance, striving to complete the overall environmental protection acceptance before 10 this year.
V Water" in the first year of the year, and issued the "Action Plan for Eliminating Inferior Class V Water in Zhejiang Province". Six major projects have been deployed, including sewage interception and receiving pipes, river dredging, industrial regulation, agricultural and rural non-point source control, discharge port regulation, ecological water distribution and restoration, vowing to completely eliminate inferior V water in 2017 . Through various measures such as the investment of environmental protection equipment, the construction and implementation of daily environmental protection management system, Jianfeng Health and Jianfeng Pharmaceutical have ensured the long-term stable discharge of various pollutants up to the standard, and have used practical actions to help eliminate inferior V water. (Reporter Ni Yingzhen)
More information
July 1 is the anniversary of the founding of the Communist Party of China. The party committee of the group organized the party members of the group headquarters and the heads of the grassroots party organizations to go to Jinggangshan, the red holy land, to retake the revolutionary road taken by the ancestors and review the history of revolutionary struggle.
2023
07-11
The Party Committee of the Group organized a thematic education seminar to study
On June 27, the Party Committee of the Group Company organized an education seminar on the theme of studying and implementing Xi Jinping's thoughts on socialism with Chinese characteristics in the new era. Jiang Xinwang, a professor and master tutor of Zhejiang Normal University, explained the deployment requirements of economic work and Xi Jinping's economic thoughts in the report of the 20th National Congress of the Communist Party of China with the theme of "accelerating the construction of a new development pattern and promoting high-quality development.
2023
07-11
Jianfeng Pharmaceutical rehired Academician Wang Guangji as Chief Scientist
On April 30, Jiang Xiaomeng, chairman of the group company and chairman of Jianfeng Pharmaceutical Company, on behalf of Jianfeng Pharmaceutical Company, issued a letter of appointment to Professor Wang Guangji, academician of the Chinese Academy of Engineering, and renewed him as the chief scientist of the pharmaceutical company.
2023
05-11
Jinhua Development Conference and Wucheng Development Conference
On April 30 and May 1, the third Jinhua Development Conference and the second Wucheng Development Conference opened successively. Jiang Xiaomeng, secretary of the party committee and chairman of the group company, won two major awards at the "Jinhua Development Outstanding Achievement Award" and "Wucheng Development Merit Award" at the two conferences, and participated in the Jinhua Life and Health Industry Summit roundtable and other activities.
2023
05-11
Daye Peak Cement Company, National "Green Factory"!
The Ministry of Industry and Information Technology recently announced the 2022 national green manufacturing list, Daye Peak Cement Company successfully ranked among the national "green factories. Green manufacturing is also known as environmentally conscious manufacturing, that is, in the manufacturing process, a modern manufacturing model that comprehensively considers environmental impact and resource benefits. Its purpose is to use technical means to optimize manufacturing procedures, minimize the impact on the environment (negative effect), and resource utilization The highest rate, and the coordination and optimization of economic and social benefits of enterprises, so as to achieve the purpose of resource conservation and sustainable development. In recent years, with the rapid development of social economy, the state attaches great importance to the construction of ecological civilization and ecological environment protection, and further promoting the construction of green manufacturing system has become an important means to promote high-quality development and maintain green water and green mountains forever. As an important part of the green manufacturing system, the Ministry of Industry and Information Technology has organized and carried out the creation of national-level green factories since 2017, and has conducted nationwide selection. It is an authoritative recognition for companies that meet the "green development" and aims to improve my country's green Manufacturing system, comprehensive implementation of green manufacturing, and help the industrial sector achieve the goal of carbon peak and carbon neutrality, it is an important way to promote the structural optimization of various industries, to get out of trouble and upgrade, and to improve quality and efficiency. Green factory refers to the realization of land intensive, raw materials harmless, clean production, waste resources, energy low-carbon factories. As the production unit of the manufacturing industry, the factory is the main body of the implementation of green manufacturing, which belongs to the core support unit of the green manufacturing system, focusing on the greening of the production process. Over the years, Daye Jianfeng has been adhering to the concept of green and low-carbon development, making every effort to build a garden-style factory. Through formulating plans and subdividing targets, it has clearly defined the total energy consumption and pollutant emission targets, and through carrying out school-enterprise cooperation to promote industry-university-research, it has actively implemented the strategy of "carbon peak and carbon neutrality", invested a huge amount of funds every year for technological transformation, and successively implemented technological transformation projects such as electric bags and low-nitrogen combustion upgrading, take the lead in the application of emission reduction technologies such as wet desulfurization and precise denitrification in the cement industry in Hubei Province, and continue to promote energy conservation, consumption reduction, and emission reduction. After the technical transformation, the company can save 3000 tons of standard coal every year, reduce the intensity of carbon dioxide emissions by 3.6, improve the level of energy-saving and green environmental protection management, and achieve the goal of creating a green factory. Being rated as a national-level green factory is not only a high affirmation and encouragement of Daye Peak's adherence to green, low-carbon and innovative development, but also an opportunity for Daye Peak to further promote green development. The person in charge of Daye Peak said that in accordance with national requirements, local industrial and information authorities should strengthen the connection between the units listed in the green manufacturing list and relevant industrial policies, give full play to the demonstration role of point to area, lead the green transformation of the manufacturing industry in the region, strengthen tracking guidance and dynamic management, and review the key indicators specified in the dynamic management table, Daye Peak will be in the future work, we will continue to further promote the management of environmental protection, energy conservation and emission reduction, give full play to the leading role of green factories in benchmarking, make low-carbon energy conservation, green environmental protection and reduce energy consumption the main keynote of enterprise development, and make continuous efforts to promote the high-quality development of enterprises and local economy. (Junin)
2023
04-03
"Cement Economy 50 People Forum" Jiang Xiaomeng Talk about the Future Development of Cement Industry
On March 14, the "Cement Economy 50 Forum" hosted by China Cement Network was held in Hangzhou, inviting 50 influential economic figures in the cement industry to discuss the future development of China's cement industry. Jiang Xiaomeng, chairman of the group company, was invited to attend the forum to discuss the development of the cement industry with his peers. The theme of this forum is "strengthening confidence, seeking breakthrough, and promoting development". It aims to point out the disadvantages of "mud", actively provide suggestions for the competent departments, enterprise transformation and upgrading, strategic and tactical decision-making in the difficult period of the cement industry, and provide new think tank opinions and methods to help form a new cement economic ecology. In the context of the sharp decline in demand, the cement industry is trapped inside and outside, how to revive the glory? How do cement companies survive and develop next? Around these two topics, the guests at the meeting had a heated discussion. Jiang Xiaomeng pointed out in his speech at the forum that the development of any enterprise is inseparable from the healthy development of the industry. Only when the industry is good can the enterprise be good, and the interests of the industry are greater than the interests of the enterprise. In addition, the competition of similar enterprises should seek a breakthrough from the differentiation, and it is unreasonable to blindly pursue low prices. Industry synergy, industry synergy, supply, demand, price, to find a common price line, on the basis of competition and cooperation, from the management services, cost control and other aspects to highlight the advantages of enterprises. The participants reached consensus on many issues after heated discussions. It is generally believed that 2022 is the most complex year in the cement industry in the past decade, affected by the multi-point spread of the epidemic, real estate downturn and other factors, the cement market demand is sluggish, the contradiction between supply and demand is prominent, prices are falling rapidly, business difficulties, the pace of steady growth of the industry is blocked. Entering 2023, under the macroeconomic situation of stabilizing the economy and promoting development, as well as various regions stepping up efforts to promote the construction of major projects, cement demand is expected to increase in 2023 compared with 2022, and the situation in the second half of the year will be better than that in the first half. However, under the expectation of restorative growth in demand, the cement industry is still facing uncertainties such as continued bottoming of real estate, high energy costs, and overcapacity. In this regard, we should resolutely maintain the normal order of the industry, make concerted efforts to help the industry get out of the predicament, and firmly implement staggered peak production. Through mergers and acquisitions, carbon quotas, energy efficiency indicators, environmental protection indicators, coal indicators, market competition and other means to further resolve the contradiction of overcapacity, optimize the industrial layout, and adhere to innovation-driven in digital, intelligent and green development, so as to promote and finally realize the high-quality development of the cement industry. (this newspaper reporter)
2023
03-21
Contact Us
No. 88 Wujiang East Road, Jinhua City, Zhejiang Province, China
Tel: +86-579-82326868
Fax : +86-579-82324666
©2023 Zhejiang Jianfeng Group Co., Ltd. Powered by: www.300.cn SEO Business License
SAF Coolest v1.2 设置面板 SHJSS-AHDB-FSSQE-ZSW
无数据提示
Sorry, the current column has no content !
You can view other columns or return to Home Page