Safety management is the foundation of enterprise
Release time:
2023-06-25
I am a safety management worker in Tianjin Jianfeng Natural Products Company. Someone once asked me, no accident is safe? Obviously not, no accident is a result, accident and safety is not relative, and risk and safety is relative. Therefore, safety management is to prevent and control risks, so that no safety accidents or minimize the loss caused by accidents.
Security risk exists objectively. It exists at any time and in any space. How to control the risk more effectively is a permanent issue of security management. The following four aspects are my core experience of safety management.
First of all, to effectively control risk, accountability and rules and regulations are the guidelines. The Safety Production Law proposes that production and business units must establish and improve the safety production responsibility system and safety production rules and regulations for all employees. Safety is the lifeline of an enterprise. The full responsibility system and the preparation of rules and regulations must be realistic. The system requires that while fully implementing laws, regulations, standards and norms, it must also be operable within the enterprise. Only in this way, the whole system from the scope of responsibility to the inspection and assessment can be fully and effectively implemented. The full safety responsibility system must be horizontal to the side and vertical to the end. From every department to every person, the full responsibility must be compacted by the management, especially the responsibility content of key positions, and the frequency of training should be increased.
Secondly, safety education and training is an important way of risk control and a concrete manifestation of the implementation of "safety first, prevention first. According to survey statistics, more than 90% of accidents are caused by unsafe behaviors of people. Failure to operate in accordance with operating procedures, ignoring safety, ignoring warning signs, incorrect use of labor protection equipment, venturing into dangerous areas, etc. are all human unsafe behaviors, and the most important way to prevent these unsafe behaviors is education and training. In safety education and training, we must resolutely overcome the coping tasks such as "scripted" and "borrowlism"; we must use various forms and fresh content to stimulate the enthusiasm of employees, activate the atmosphere of education and training, and appropriately carry out award-winning contests and other activities to increase the enthusiasm of employees in training and achieve better training results. In addition, the daily management process should also regularly check and assess education and training, check whether the relevant departments are carried out as scheduled in accordance with the annual training plan, check the implementation of the three-level education of employees, and urge relevant departments and personnel to complete education and training through assessment. The cost of safety training is very low, but the cost of accidents is very high. Only by earnestly implementing education and training can the overall quality of the workforce be improved. When employees master the knowledge of safety production, their natural safety awareness will be improved, and the possibility of accidents will be greatly improved. Reduced.
Third, do a good job in risk classification control and hidden danger investigation and management, and build two firewalls for safe production. Risk identification is the basis of risk classification and control. Enterprises should improve the ability of employees to identify and control risks through training. They should participate in all employees, the whole process and all directions, and make a list for each post to fully identify. Safety management personnel should scientifically and rigorously analyze each hazardous material, each hazardous equipment and each operation activity, and accurately prevent and control them after classification. The second firewall, hidden danger investigation and management should be organically integrated with risk classification and control. Through risk analysis and evaluation results, a list of hidden danger investigation should be formulated, a hidden danger investigation plan should be prepared, and hidden danger management should be carried out after hidden danger investigation, so as to eliminate hidden dangers from the source or reduce the possibility of accidents.
Fourth, do a good job in emergency management. In recent years, a large part of the many major accidents that have occurred in China is that they have not done a good job in emergency management, companies have not conducted drills, do not understand the handling methods of abnormal working conditions, and employees lack emergency knowledge, which has caused major disasters and brought huge disasters to families. The grief has brought huge losses to the enterprise. Therefore, enterprises should strengthen emergency management, focusing on the management of the four stages of prevention, preparation, accident response and recovery. The emergency rescue plan should be taken as the core, and the whole process of management should be carried out for all kinds of dangerous situations, dangerous events and accidents from the construction of emergency team, emergency material reserve, personnel education and training, plan drill, danger warning to accident emergency disposal. Through emergency drills, the emergency response ability and evacuation speed of employees are tested, the cooperative combat ability and level of each emergency team are improved, and various operation safety precautions, scientific rescue methods and skills are mastered. At the same time, the feasibility of the emergency plan is also tested. Provide a basis for revising the plan. Therefore, only by doing a good job in emergency management can we be fearless in the face of danger, deal with chaos, and build the last line of defense for enterprises to secure production safety.
Safety management is the foundation of an enterprise. It is advisable to take precautions before rain and dig wells before thirst. As a safety manager, we must always be in awe of safety management, and constantly explore new safety management ideas with a never-slack spirit, so as to provide a solid guarantee for the sustainable development of enterprises. (Tian Chenhui)
More information
Recently, it was learned from the competent department that the "ERP/MES full-process informatization" project of Jianfeng Pharmaceutical Company has been included in the list of key projects of "integration of industrialization and industrialization" in Jinhua City, and has now entered the publicity period. In order to speed up the in-depth integration of informatization and industrialization, according to the evaluation criteria in Jinhua City's "Several Opinions on Accelerating Informatization Construction" and "Jinhua City Informatization and Industrialization Integration Key Project Management Measures", 148 projects were included in 2017 Jinhua City's "Integration of Industrialization and Industrialization" key projects. The "ERP/MES Full Process Informatization" project of Jianfeng Pharmaceutical Co., Ltd. was finally included in the list after being recommended, material reviewed and expert reviewed by Jinhua Economic and Information Committee. The ERP-level subsystems of ERP/MES full-process informatization project include sales system, procurement system, MRP system, GMPQbD system, connecting UFIDA financial software and HR system. MES-level subsystems include industrial data acquisition and monitoring system, GAMP/MES system, eBPR (electronic batch production record system), cGMP quality assurance system, QC/eBTR(QC process and electronic batch inspection record system), LIMS system, etc. After the construction is completed, the visualization of drug production process and the collection and integration of industrial data will be realized. Realize the electronization of drug production process parameters, electronic batch production and inspection records; the realization of big data integration of industrial data and information will also be in line with the regulatory concept of GMP data integrity and quality traceability to the greatest extent. The establishment of a unified enterprise information platform will eliminate information islands and realize data one.
2020
07-31
The company's first-half profit record high
According to the 15th meeting of the ninth board of directors of the company on August 25, in the first half of 2017, the company achieved a net profit of 240.5357 million yuan, the highest level in half a year's history. In the first half of 2017, the company focused on the general work policy of "grasping trends, precise development, strengthening management, and improving efficiency", grasping the opportunities brought by economic structure optimization and industrial upgrading, strengthening lean production and management improvement internally, and actively exploring externally Develop new opportunities and continue to promote the "three reductions and three improvements" work. Through the joint efforts of all employees of the company, the best semi-annual performance in history has been achieved. As of the end of June 2017, the company's total assets were 4.226 billion yuan and net assets were 2.511 billion yuan; the company achieved total operating income of 1,305.9327 million yuan, an increase of 18.42 percent over the same period last year, and net profit attributable to owners of the parent company was 240.5357 million yuan, an increase of 132.11 percent over the same period last year. Earnings per share are 0.7 yuan. In the second half of the year, the company will continue to focus on the annual business plan, carry out in-depth work of "three reductions and three improvements", further do a good job in internal control, prevent business risks, and further do a good job in safety and environmental protection. we will further develop and improve the complementary relatively diversified main business structure and constantly enhance the company's core competitiveness. The 15th meeting of the 9th board of directors held on August 25 was presided over by Jiang Xiaomeng, chairman of the group company. Four proposals and reports including the 2017 semi annual report and the proposal on the change of the company's accounting policy were deliberated and passed. on the same day, the 12th meeting of the eighth board of supervisors was held,
2020
07-31
General Manager Yu Jianhong to Yunnan Peak to Guide Work
On August 23, Yu Jianhong, general manager of the group company, went to Yunnan Jianfeng cement company for investigation and guidance, and put forward requirements for the key work in the last few months of this year. At the peak of Yunnan Province, Yu Jianhong went deep into the production site to learn more about the current production and operation situation, and convened the middle-level and above management backbones to have in-depth exchanges and discussions with everyone on the problems existing in work efficiency changes, personnel stability, current production and management after the implementation of post optimization and re-organization. Since the beginning of this year, Yunnan's peak production and sales volume, profits and various technological and technical indicators have been relatively ideal. The kiln output in April has also reached the best level since it was put into production. The development and maintenance of the market, the environmental management of the factory area, and the professional quality and mental state of cadres and workers have also been greatly improved. While fully affirming the above achievements, Yu Jianhong pointed out that as the homogenization of the cement market becomes more and more serious, the market changes faster and faster. If we can't recognize the situation and seize the opportunity, enterprises will face more and more problems. In this case, the management backbone should give full play to the role of the backbone, quickly change the management concept, and strive to improve the competitiveness of enterprises. In view of the focus of work in the last four months of this year, Yu Jianhong put forward the following requirements for Yunnan Jianfeng: break the inherent concept of post functions and responsibilities, set up posts and organizational structures around logistics, people flow and capital flow, and cultivate and forge a team that can fight well. To further implement the training of job skills and quality, managers should take the lead in strengthening their own learning and formulate annual, monthly and weekly training plans, through the combination of internal and external training, theory and practice.
2020
07-30
General Manager Yu Jianhong to Yunnan Peak to Guide Work
On August 23, Yu Jianhong, general manager of the group company, went to Yunnan Jianfeng cement company for investigation and guidance, and put forward requirements for the key work in the last few months of this year. At the peak of Yunnan Province, Yu Jianhong went deep into the production site to learn more about the current production and operation situation, and convened the middle-level and above management backbones to have in-depth exchanges and discussions with everyone on the problems existing in work efficiency changes, personnel stability, current production and management after the implementation of post optimization and re-organization. Since the beginning of this year, Yunnan's peak production and sales volume, profits and various technological and technical indicators have been relatively ideal. The kiln output in April has also reached the best level since it was put into production. The development and maintenance of the market, the environmental management of the factory area, and the professional quality and mental state of cadres and workers have also been greatly improved. While fully affirming the above achievements, Yu Jianhong pointed out that as the homogenization of the cement market becomes more and more serious, the market changes faster and faster. If we can't recognize the situation and seize the opportunity, enterprises will face more and more problems. In this case, the management backbone should give full play to the role of the backbone, quickly change the management concept, and strive to improve the competitiveness of enterprises. In view of the focus of work in the last four months of this year, Yu Jianhong put forward the following requirements for Yunnan Jianfeng: break the inherent concept of post functions and responsibilities, set up posts and organizational structures around logistics, people flow and capital flow, and cultivate and forge a team that can fight well. To further implement the training of job skills and quality, managers should take the lead in strengthening their own learning and formulate annual, monthly and weekly training plans, through the combination of internal and external training, theory and practice.
2020
07-31
Spike Pharmaceuticals set out to explore a new sales model
Agency and Terminal Link Production and Chain Cooperation Spike Pharmaceuticals to Explore New Sales Models From August 16 to 21, the 2017 China Pharmaceutical Retail Industry Information Conference (hereinafter referred to as "Xipu Conference") with the theme of "Building a Blueprint-Market Awakening Focusing on Demand" was held in Boao, Hainan. Huang Jinlong, deputy general manager of the group company and general manager of the pharmaceutical company, and relevant leaders of Spike Health, pharmaceutical sales company and Spike Pharma pharmacy were invited to attend the event, to create a new sales model "road". This year coincides with the 10th anniversary of the Western Conference. More than 1200 mainstream chain pharmacies, more than 800 brand pharmaceutical industries, more than 100 cross-border affiliated institutions, more than 130 top domestic and foreign capital institutions, more than 60 representatives of authoritative media, and authoritative experts in the industry, with nearly 4000 people gathered in Boao. The meeting combed the context of the pharmaceutical retail industry in the past ten years, discussed the development of the industry in the new decade, and built a new blueprint for the industry. During the meeting, Huang Jinlong led the peak participants to have in-depth exchanges with the organizers of the conference and industry experts on issues such as the impact of national policies such as the brand strategy of enterprises, the role of brand enterprises in the industry, medical reform, prescription outflow, etc. on the original sales mode of pharmaceutical enterprises. He also had extensive contact with pharmaceutical counterparts and terminal chains, listened to front-line sales experience, collected relevant information on terminal chains, and collected market trends of the top 100 chains. In the past ten years, the scale of drug retail sales in China has increased from 143 billion yuan to 337.7 billion yuan, and the chain rate has increased from 35.3 percent to 49.4 percent.
2020
07-31
General Manager Yu Jianhong to Yunnan Peak to Guide Work
On August 23, Yu Jianhong, general manager of the group company, went to Yunnan Jianfeng cement company for investigation and guidance, and put forward requirements for the key work in the last few months of this year. At the peak of Yunnan Province, Yu Jianhong went deep into the production site to learn more about the current production and operation situation, and convened the middle-level and above management backbones to have in-depth exchanges and discussions with everyone on the problems existing in work efficiency changes, personnel stability, current production and management after the implementation of post optimization and re-organization. Since the beginning of this year, Yunnan's peak production and sales volume, profits and various technological and technical indicators have been relatively ideal. The kiln output in April has also reached the best level since it was put into production. The development and maintenance of the market, the environmental management of the factory area, and the professional quality and mental state of cadres and workers have also been greatly improved. While fully affirming the above achievements, Yu Jianhong pointed out that as the homogenization of the cement market becomes more and more serious, the market changes faster and faster. If we can't recognize the situation and seize the opportunity, enterprises will face more and more problems. In this case, the management backbone should give full play to the role of the backbone, quickly change the management concept, and strive to improve the competitiveness of enterprises. In view of the focus of work in the last four months of this year, Yu Jianhong put forward the following requirements for Yunnan Jianfeng: break the inherent concept of post functions and responsibilities, set up posts and organizational structures around logistics, people flow and capital flow, and cultivate and forge a team that can fight well. To further implement the training of job skills and quality, managers should take the lead in strengthening their own learning and formulate annual, monthly and weekly training plans, through the combination of internal and external training, theory and practice.
2020
07-31
Contact Us
No. 88 Wujiang East Road, Jinhua City, Zhejiang Province, China
Tel: +86-579-82326868
Fax : +86-579-82324666
©2023 Zhejiang Jianfeng Group Co., Ltd. Powered by: www.300.cn SEO Business License
SAF Coolest v1.2 设置面板 SHJSS-AHDB-FSSQE-ZSW
无数据提示
Sorry, the current column has no content !
You can view other columns or return to Home Page